Looking for help/advice on truck ...

[Rawze]

So,. This person stopped by here this Easter weekend. Really nice person by the way, I enjoyed their company. I help them review their programming. It was horrible to say the least. SOme company in Pensilvania did it that does a lot of delete programming and pushes the fixed-vane turbo's etc.. like a bunch of complete idiots.


It is the typical bad CM2350 delete seen spreading all over the internet here lately... same issues ...


* The SCR can was never hollowed out. It got so clogged up with soot that it was causing harm to the engine and turbo.

* Programming was horrible. The typical 'Jail-Break', set as few settings as possible to get the alarms out of the dash and hope-for-the-best type of engine destroying programming.

- engine still going straight into SCR and exhaust component warm-up modes, it never being satisfied ... causing all kinds of extra heat in the exhaust all the time... engine fighting the turbo.

- Injection timing in all operating modes way too high for the now blocked-off egr gas.

- not a single engine mode, was the egr gas requests removed from the programming at all.

- Even the little bit of stuff that was hap-hazardly switched off was so incomplete that it was not even funny. Horribly done.


The list of problems and incomplete things done incorrectly is quite long. This is the typical half-arssed de-mandate program attempts that has been seen here lately... I swear these morons are getting lazier and lazier. ... Welcome to the bad delete club...

THEY ALSO DID NOT do the hardware mods correctly...

* They did not remove the Intake air throttle valve, it was causing low boost problems... even though the turbo was over-spooling all the time to try to overcome it.

* They also did not hollow out the SCR canister. - This truck has run for 4 months, slowly loosing power and fuel mileage slowly dropping off.. then some of the gaskets between the exhaust cans blew out causing a massive exhaust leak under the passenger steps opf the truck. - THIS IS BECAUSE THE IDIOTS WHO DID THE DELETE DID NOT HOLLOW OUT THE SCR CAN AND TOLD THE TRUCK OWNER THAT IT WAS A PASSIVE DEVICE AND THAT IT DID NO0T NEEDD IT! -- HERE IS WHAT THIS TRUCKS OWNERS SCR CAN FACE LOOKED LIKE AFTER 4 MONTHS OF THIS NONSENSE LAZYNESS GARBAGE!!!!...
       
100% BLOCKED UP AFTER 4 MONTHS OF RUN TIME!!!

-- HE IS LUCKY HE HAD NOT LOST HIS ENTIRE ENGINE YET! due to the completely face-plugged SCR CANISTER that the delete shop idiots told him was not necessary to do... I SEE THIS WAY TOO OFTEN.. THESE DELETE SHOPS ARE COMPLETE RETARDS IF THEY THINK THAT SCR CAN IS GOING TO STAY CLEAN ALL ON ITS OWN!!!

-- really... I just don;t get it.... I shake my head in dismay at how utterly stupid these places really are.